2019 KTM 790 Adventure Recalls, Problems & Safety Rating

2 safety recalls on file

The 2019 KTM 790 Adventure has 2 safety recalls on file with NHTSA.

Owners have filed 12 complaints with NHTSA.

The most-reported problem area is Service Brakes (9 reports).

2Recalls
12Owner complaints
0Crashes reported
n/aNHTSA safety rating
Is the repair still open on your 790 Adventure?

A recall covers specific vehicles. Your VIN shows whether yours still needs the free repair.

2019 KTM 790 Adventure recalls

Weak Front Brake Spring Can Reduce Stopping Power

Recall 21V304Apr 30, 20213,707 vehicles affected

The front brake master cylinder on these motorcycles may have a return spring that is too weak.

Rear brake hose can overheat and cause rear brake failure

Recall 20V198Apr 6, 20203,164 vehicles affected

The rear brake hose on these motorcycles may overheat.

Most common 2019 KTM 790 Adventure problems

Problem areas named in the 12 complaints owners filed with NHTSA.

Problem areaReports
Service Brakes9
Engine3
Wheels2
Steering1
Vehicle Speed Control1
Power Train1
Exterior Lighting1

What owners report

2024-11-26, Engine
August 14, 2024. My KTM 790 Adventure left me stranded on side of highway due to motor failure. 14,440 miles on odometer. Oil pressure light on dash lit up. 3rd oil change of its life. Had bike towed home and then dropped off at dealer on Sept 7th 2024 and the inspection was performed on 9-25-24, was charged for valve inspection. Dealer agreed valves, lifters and head were damaged and matched my description of failure. Case was opened with KTM USA , KTM denied me their 'Goodwill scheme" due to dust/dirt in motor. Appeal filed with KTM and that was also denied. This is a known faulty head in the motor that left me stranded on the side of a major highway. I received back at time of pickup a b
2024-05-29, Exterior Lighting
Failed brake light switches cause brake light to not operate. Fails state safety inspection .
2022-11-29, Service Brakes
The brake light doesn't illuminate unless excessive brake pressure is used. During normal braking the light doesn't illuminate at all when using the front or rear brake. It is available for inspection upon request. My safety and safety of others has been put at risk because other motorists will not know that i'm braking since the light doesn't illuminate. The problem has been reproduced by me. The KTM dealer will not offer free diagnostics for this even though there have been two other brake recalls for this model. This has only been inspected by me and multiple other owners who hav encountered the same issue. There were no warnings or symptoms prior to the issue.
2022-08-18, Power Train
The clutch quit engaging while in traffic and I was nearly stranded on I-25 in stop and go traffic. I was able to nurse it along to a nearby parking lot with the clutch slipping very badly. I could have easily been rear ended. I took it apart and found the wet-clutch system was not getting any oil, it was completely dry. I bought a new clutch pack and cleaned the oil jet that supplies the clutch with oil. The clutch worked fine after oiling and installing it. It started slipping badly only a few hundred miles later. I took it apart and the clutch was completely dry again and the clutch oil jet was clogged. I replaced the stock clutch oil jet with an enlarged one and it has worked
2022-01-21, Engine
The contact owns a 2019 KTM 790 Adventure Motorcycle. The contact stated that several attempts were needed to start the vehicle. While driving at low speeds and applying the throttle, the vehicle stalled. The vehicle was taken to the local dealer five times where it was diagnosed that a new fuel pump, new fuel hose, clamps, fuel line, fuel connector, fuel injectors and smog kit and power-washed tank were needed. Additionally, there was build-up in the throttle body. The vehicle was repaired however, the failure recurred. The manufacturer was notified but, no further assistance was provided. The approximate failure mileage was 2,382.

2019 KTM 790 Adventure questions

Does the 2019 KTM 790 Adventure have any recalls?

Yes. NHTSA lists 2 safety recalls for the 2019 KTM 790 Adventure: Weak Front Brake Spring Can Reduce Stopping Power; Rear brake hose can overheat and cause rear brake failure. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2019 KTM 790 Adventure?

Based on 12 owner complaints filed with NHTSA, the most-reported problem areas are Service Brakes (9), Engine (3), Wheels (2).

How do I check if a recall on my 2019 KTM 790 Adventure has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.

Other KTM 790 Adventure years

Other 2019 KTM models