CarRecallWatchThe 2009 Keystone Cougar has 3 safety recalls on file with NHTSA.
Owners have filed 4 complaints with NHTSA.
The most-reported problem area is Structure (3 reports).
2009 Keystone Cougar recalls
Fire extinguisher may fail to discharge or spray in a fire
Some Kidde plastic-handle and push-button fire extinguishers installed in these recreational trailers may become clogged, so they may not discharge as expected, or may require excessive force to activate.
Most common 2009 Keystone Cougar problems
Problem areas named in the 4 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Structure | 3 |
| Tires | 2 |
| Unknown Or Other | 1 |
What owners report
THE WELDS ON THE SPARE TIRE CARRIER START TEARING FROM IT BEING TIGHTENED TO MUCH TO THE REAR BUMPER CAUSING THE SPARE TIRE TO START LEANING IN A BACK POSITION. IF THE CARRIER IS NOT REPLACED , THE SPARE TIRE WILL FALL OFF WHEN THE WELDS COMPLETELY BRAKE (THIS IS LIKELY TO HAPPEN WHEN THE VEHICLE IS IN MOTION) . *TR
HELLO, I PURCHASED A 2009 KEYSTONE COUGAR 318SAB ON JUNE 7, 2013. DURING THE FINAL WALK THRU INSPECTION, I NOTICED THE SPARE TIRE CARRIER WAS CRACKED AND THE TIRE WOBBLING AROUND. THE DEALER, RUFF'S RV IN EUCLID, OH SAID THEY WOULD TRY TO GET ME A NEW SPARE TIRE CARRIER. A FEW WEEKS HAS GONE BY, AND I HAVE NO REPLACEMENT CARRIER. I THEN SEARCHED ONLINE AND FOUND A KEYSTONE SAFETY RECALL: 10V-063. THIS RECALL IS EXACTLY WHAT HAS HAPPENED TO MY UNIT, EXCEPT THAT I HAVE 15" TIRES INSTEAD OF 16" TIRES. I THEN CALLED KEYSTONE AND WAS TOLD MY RV IS NOT INCLUDED IN THE RECALL. I TOLD THE WOMAN THAT MY RV HAS THE EXACT PROBLEM AS THE RECALL, BUT SHE INSISTED THERE WAS NOTHING WRONG. HOW CAN THIS BE
WHILE TRAVELING AT 60 MPH, I OBSERVED TRAILER WAS SITTING LOWER THAN NORMAL AND CLOSE TO BED OF TRUCK. ON STOPPING AND INSPECTING I OBSERVED PIN BOX WAS TILTED UPWARD AND NO LONGER LEVEL. IMMEDIATELY STOPPED AND DISCONNECTED TRAILER. INSPECTED PINBOX AT FRAME AND FOUND STEEL TEARING AWAY FROM FRAME AT WELDS. FURTHER INSPECTION THROUGH REMOVAL OF SHROUD SHOWED FRONT CROSS MEMBER ARCHED UPWARD CLOSE TO 6 INCHES FROM HORIZONTAL. ENTIRE PINBOX NEARLY SEVERED FROM MAIN FRAME WHICH WOULD HAVE RESULTED IN TOTAL TRAILER SEPARATION AND PENITENTIAL DEATH AND INJURY TO OTHERS AND MYSELF. CONTACTED LOCAL CERTIFIED WELDER WHO STATED STEEL SHOWED SIGNS OF FATIGUE INDUCED BY INSUFFICIENT SIZE AND POOR WELD
THE AREA OF THE FRAME WHERE THE PIN BOX ATTACHES FAILED. ACCORDING TO THE REPAIR SHOP, THE WELDS WERE NOT DONE CORRECTLY WHEN IT WAS MANUFACTURED. MULTIPLE AREAS OF POOR WELD PENETRATION WERE EVIDENT IN THE FRAME FAILURE AREA, AND THE RESULTING FAILURE ALLOWED THE HITCH TO DISCONNECT FROM 75% OF ONE FRAME RAIL AND ABOUT 50% OF THE REMAINING FRAME RAIL. AN INTERNET SEARCH HAS REVEALED MULTIPLE INSTANCES OF SIMILAR FAILURE OF LIPPERT COMPONENTS FRAMES USED BY VARIOUS MANUFACTURES. ACCORDING TO THE REPAIR SHOP THIS SAME PROBLEM WAS THE SUBJECT OF A RECALL IN 1999 ON CARRIAGE 5TH WHEEL TRAILERS.
2009 Keystone Cougar questions
Does the 2009 Keystone Cougar have any recalls?
Yes. NHTSA lists 3 safety recalls for the 2009 Keystone Cougar: Fire extinguisher may fail to discharge or spray in a fire; Equipment:Other:Labels; Tires:Temporary/Emergency Spare Tire. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2009 Keystone Cougar?
Based on 4 owner complaints filed with NHTSA, the most-reported problem areas are Structure (3), Tires (2), Unknown Or Other (1).
How do I check if a recall on my 2009 Keystone Cougar has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.