2007 Itasca Navion Recalls, Problems & Safety Rating

2007 Itasca Navion recalls

Most common 2007 Itasca Navion problems

Problem areas named in the 5 complaints owners filed with NHTSA.

Problem area	Reports
Engine And Engine Cooling	4
Power Train	1
Steering	1
Fuel/Propulsion System	1

What owners report

2017-08-29, Fuel/Propulsion System
FAILURE OF THE PLASTIC TURBO NOISE DAMPENER CAUSED IMMEDIATE LOSS OF POWER AND PLACING US IN A PRECARIOUS SITUATION WHILE GOING UPHILL ON A BUSY HIGHWAY.

2012-04-17, Engine And Engine Cooling
CONSUMER WRITES IN REGARDS TO EARLY FAILURES ON MERCEDES 642 V6 ENGINE *TGW THE CONSUMER PURCHASED A WINNEBAGO NAVION MOTORHOME WHICH CAME EQUIPPED WITH AN ENGINE MANUFACTURED BY MERCEDES. THE CONSUMER STATED THE RV STARTED TO SHIFT IN A STRANGE MANNER AFTER A FEW HUNDRED MILES, THEN AFTER A THOUSAND MILES, THE SHIFTING BECAME VERY ERRATIC, SO THE CONSUMER DID MOSTLY MANUALLY SHIFTING. AFTER THE EGR WAS REPLACED, THE RV SHIFTED FINE. HOWEVER, AT 23,576 MILES, THE POWER STEERING PUMP FAILED AND TWO PINS THE HELD THE PUMP IN PLACE FAILED. *JB

2010-07-17, Engine And Engine Cooling
THE TURBO RESONATORS ON 2002-2007, 2.7 MERCEDES BENZ DIESEL ENGINES ARE DEFECTIVE! I AM ON MY THIRD ONE, AND I ONLY HAVE 15,000 MILES ON MY ENGINE, WHICH IS IN A 2007 ITASCA NAVION MOTOR HOME. WHEN THEY GO OUT ON THE INTERSTATE, YOU ARE PUT IN A VERY DANGEROUS SITUATION BECAUSE YOU CANNOT GO OVER 45 MPH, AND YOU'RE LIFE IS PUT IN DANGER. I HAVE EMAILED MERCEDES BENZ/DODGE/WINNEBAGO AND THEY SAY THEY DON'T HAVE A PROBLEM, BUT THEY DO!! I HAVE GONE ONLINE SEARCHING OUT THIS DEFECT AND COULD NOT BELIEVE THE NUMBER OF PEOPLE WHO HAVE EXPERIENCED THIS SAME LIFE OR DEATH SITUATION, DUE TO THEIR TURBO RESONATOR GOING BAD. IT SEEMS THAT THIS WARRANTS A RECALL, TO FIX THIS DANGEROUS DEFECTIVE PROD

2010-06-02, Engine And Engine Cooling
I HAVE A 2007 ITASCA NAVION WITH A 2.7 MERCEDES BENZ DIESEL ENGINE ON A DODGE SPRINTER CHASSIS. THIS PAST SATURDAY, MAY 29, 2010, I HAD TO TAKE MY RV INTO KINGS DODGE TO HAVE MY THIRD RESONATOR REPLACED BECAUSE WHEN ONE GOES OUT, YOU CANNOT GO OVER 45 MPH ON THE INTERSTATE, AND THIS IS DANGEROUS. MY RV ONLY HAS 15,649 MILES ON IT!, SO I THINK THAT A RECALL NEEDS TO BE MADE, BY YOU, SO MERCEDES BENZ CORRECTS THIS RESONATOR PROBLEM. I GOT ONLINE WITH THIS PROBLEM AND COULD NOT BELIEVE THE NUMBER OF RESONATOR COMPLAINTS THERE WERE. THANK YOU FOR YOUR HELP.. *TR

2007-07-19, Engine And Engine Cooling
WHILE DRIVING ON THE EXPRESSWAY IN MY 2007 ITASCA NAVION, THE TURBO RESONATOR FAILED. THAT CAUSED THE SPEED TO DROP QUICKLY TO 40 MPH. I NEARLY AVOIDED AN ACCIDENT WITH A TRUCK THAT WAS BEHIND ME. THE PART IS MADE OF PLASTIC AND IS IN A HOT ENVIRONMENT. THE SEAMS SEPARATE AND CAUSES THE VEHICLE TO GO INTO LIMP HOME MODE. THIS DEFECT HAS BEEN DISCUSSED WIDELY IN SEVERAL INTERNET FORUMS. THE PART WAS REPLACED BY A DODGE SPRINTER DEALER AND THE PARTS MAN SAID THAT THEY HAVE REPLACED MANY OF THEM. *TR

2007 Itasca Navion questions

Does the 2007 Itasca Navion have any recalls?

Yes. NHTSA lists 1 safety recall for the 2007 Itasca Navion: Seat Belts. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2007 Itasca Navion?

Based on 5 owner complaints filed with NHTSA, the most-reported problem areas are Engine And Engine Cooling (4), Power Train (1), Steering (1).

How do I check if a recall on my 2007 Itasca Navion has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.