2012 Ford Transit Connect Recalls, Problems & Safety Rating

2012 Ford Transit Connect recalls

Most common 2012 Ford Transit Connect problems

Problem areas named in the 26 complaints owners filed with NHTSA.

Problem area	Reports
Engine	6
Visibility	5
Visibility/Wiper	4
Electrical System	4
Electronic Stability Control (Esc)	2
Seat Belts	2
Seats	2
Fuel System, Gasoline	2
Tires	2
Structure	2

What owners report

2026-01-08, Structure
The contact owns a 2012 Ford Transit Connect. The contact stated that while the vehicle was parked, the contact became aware that the front driver’s and front passenger’s seat belts were damp following a rainstorm. Upon inspection, the contact observed that the door seals on both front doors were allowing water to enter the vehicle, causing the seat belts to become damp. The vehicle was taken to a dealer; however, it was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 116,838.

2024-04-20, Electrical System
1. The heat shielding around the exhaust system failed to protect the fuel tank from exhaust heat. Heat from the exhaust system melted holes in the fuel tank, causing fuel to leak from the tank. The parts are at the Ford dealer with the vehicle. 2. The fuel tank developed leaks when it melted, causing a risk of fire or explosion. 3. The dealer confirmed that the fuel tank melted and leaked due to heat from the exhaust system. In diagnosing the issue, they refilled the fuel tank and it continued to leak. 4. To my knowledge, the vehicle or components have not been inspected by the manufacturer, police, insurance representatives, or others. My insurance chose not to be involved since it does

2022-10-13, Seat Belts
The seat belt buckle/latch in the backseat is a dangerous defective design that can cause injury. It is available for inspection, see photos provided. Merely taking a seat can result in a bruised or broken coccyx. The car was parked when the incident occurred. No, the problem has not been reproduced by a dealer or independent service center. No, the component has not been inspected by the manufacturer, police, insurance reps or others. No, there are no warnings or messages. The danger is inherent in the design.

2022-07-07, Visibility
The contact's boyfriend owns a 2012 Ford Transit Connect. The contact stated that while her boyfriend was driving 25 MPH, the windshield wiper arms failed to operate. Upon investigation, the contact discovered NHTSA Campaign Number: 12V374000 (Visibility) which she linked to the failure. The dealer and the manufacturer were notified of the failure and informed her that the vehicle was not under recall. The vehicle was not repaired. The failure mileage was approximately 200,000.

2022-04-17, Tires
I noticed the 2 rear P205/65R15 (with approximately 4,500 mi) had a small dip in the sidewall. Typically evident of belt breaks or some other defect. About four weeks later, the front 2 p205/65R15 (with approximately 2,500 mi) also display this same dip in the sidewall. I’ve not had a problem with any 4 tires to date, all tires are still installed in my vehicle and available for inspection. I have not had these examined by a service center yet.

2012 Ford Transit Connect questions

Does the 2012 Ford Transit Connect have any recalls?

Yes. NHTSA lists 1 safety recall for the 2012 Ford Transit Connect: Visibility:Windshield Wiper/Washer. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2012 Ford Transit Connect?

Based on 26 owner complaints filed with NHTSA, the most-reported problem areas are Engine (6), Visibility (5), Visibility/Wiper (4).

How do I check if a recall on my 2012 Ford Transit Connect has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.