1992 Ford Econoline Recalls, Problems & Safety Rating

1992 Ford Econoline recalls

Most common 1992 Ford Econoline problems

Problem areas named in the 83 complaints owners filed with NHTSA.

Problem area	Reports
Vehicle Speed Control	19
Electrical System	14
Fuel System, Gasoline	14
Engine And Engine Cooling	13
Service Brakes, Hydraulic	11
Suspension	8
Steering	7
Power Train	5
Wheels	5
Tires	4

What owners report

2014-04-02, Vehicle Speed Control
TL* THE CONTACT OWNS A 1992 FORD ECONOLINE. THE CONTACT STATED THAT A FIRE IGNITED FROM UNDER THE HOOD AS THE VEHICLE WAS PARKED. THE CONTACT EXTINGUISHED THE FIRE AND THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHO STATED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 008V051000(VEHICLE SPEED CONTROL) THAT COULD HAVE BEEN RELATED TO THE FAILURE HOWEVER, THE CONTACT'S VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

2010-06-16, Electrical System
TL* THE CONTACT OWNED A 1992 FORD ECONOLINE VAN. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD AN UNUSUAL NOISE AND ASSUMED ONE OF THE TIRES WAS FLAT. AS HE WAS MOVING THE VEHICLE OFF THE ROADWAY, THE VEHICLE CAUGHT ON FIRE FROM THE DRIVER'S SIDE. THE FIRE DEPARTMENT WAS CALLED AND A REPORT WAS FILED. THE POLICE ARRIVED BUT THEY DID NOT FILE A REPORT. THE VEHICLE WAS DESTROYED. NO ONE WAS INJURED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

2008-09-02, Latches/Locks/Linkages
PROBLEM: DOOR LATCHES ON THREE OF SIX DOORS ON 1992 FORD ECONLINE CONVERSION VAN FAILED SUDDENLY WITHIN FOUR DAYS OF EACH OTHER PREVENTING DOORS FROM BEING OPENED. SAFETY HAZARD: DOORS NOT OPENING COULD PREVENT EGRESS FROM VEHICLE IN EVENT OF AN ACCIDENT. FAILURE CAUSE: DETERIORATION OF PLASTIC RETAINERS AT BOTH END OF DOOR MECHANISM CABLES. FOUR RETAINERS ARE MOLDED TO EACH END OF TWO CABLES INSIDE THE DOOR. FAILURE OF THE RETAINERS PREVENTS DOORS CABLES FROM FUNCTIONING PROPERLY TO OPEN DOORS. IN ALL THREE CASES EACH OF THE FOUR RETAINS IN ALL THREE DOORS FAILED SIMULTANEOUSLY. REPAIRS: FOLLOWING THE FIRST FAILURE, THE VEHICLE WAS TAKEN TO A MECHANIC WHO ADVISED THAT REPLACEMENT R

2008-07-28, Vehicle Speed Control
TL*THE CONTACT OWNS A 1992 FORD ECONOLINE. THE CONTACT HAD HIS CRUISE CONTROL DEACTIVATED IN FALL OF 2007 ACCORDING TO NHTSA CAMPAIGN ID NUMBER 08V051000 (VEHICLE SPEED CONTROL:CRUISE CONTROL), WHICH COULD CAUSE A FIRE. HE THEN HAD THE NEW AND IMPROVED CRUISE CONTROL PART INSTALLED IN THE SUMMER OF 2008. AFTER THE INSTALLATION, HE NOTICED THAT THE CRUISE CONTROL WAS NO LONGER OPERATIVE. THE MANUFACTURER STATED THAT THEY WOULD STAND BY THEIR REPAIR AND HONOR A REPLACEMENT FOR THE FAILURE; HOWEVER, THE CONTACT WOULD HAVE TO PAY FOR THE DIAGNOSTIC IN ADDITION TO ANY OTHER EXPENSES OTHER THAN THE JUMPER HARNESS. THE CURRENT MILEAGE WAS APPROXIMATELY 101,850 AND FAILURE MILEAGE WAS 99,966.

2008-05-29, Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 1992 FORD ECONOLINE. AFTER STARTING THE VEHICLE, THE WATER PUMP BEGAN LEAKING FLUID. THE LABOR COST FOR THE REPAIR WAS $100. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL. THE PEDAL EXTENDED TO THE FLOOR AND MADE IT VERY DIFFICULT TO STOP THE VEHICLE. WHILE THE MECHANIC WAS INSPECTING THE VEHICLE, HE OBSERVED AN INCOMPLETE STICKER INSIDE THE DOOR BY THE MANUFACTURER IN 1992. THE CONTACT WAS CONCERNED THAT THE STICKER INDICATED THAT THERE WERE SOME PARTS ON THE VEHICLE THAT WERE NOT COMPLETELY INSTALLED. THE CONTACT STATED THAT THE FRONT END ALSO NEEDED TO BE ALIGNED. THE VEHICLE WAS PURCHASED 1 YEAR AGO. THE CURRENT AND FAILURE MILEAG

1992 Ford Econoline questions

Does the 1992 Ford Econoline have any recalls?

Yes. NHTSA lists 3 safety recalls for the 1992 Ford Econoline: Vehicle Speed Control:Cruise Control; Fuel System, Gasoline; Equipment:Other:Labels. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 1992 Ford Econoline?

Based on 83 owner complaints filed with NHTSA, the most-reported problem areas are Vehicle Speed Control (19), Electrical System (14), Fuel System, Gasoline (14).

How do I check if a recall on my 1992 Ford Econoline has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.