CarRecallWatchThe 1993 Ford Aerostar has 2 safety recalls on file with NHTSA.
Owners have filed 374 complaints with NHTSA, including 37 crashes, 38 fires, 35 injuries.
The most-reported problem area is Electrical System (110 reports).
1993 Ford Aerostar recalls
Most common 1993 Ford Aerostar problems
Problem areas named in the 374 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Electrical System | 110 |
| Service Brakes, Hydraulic | 77 |
| Power Train | 75 |
| Air Bags | 38 |
| Engine And Engine Cooling | 34 |
| Equipment | 28 |
| Structure | 25 |
| Suspension | 25 |
| Vehicle Speed Control | 24 |
| Steering | 20 |
What owners report
TL* THE CONTACT OWNS A 1993 FORD AEROSTAR. WHILE DRIVING AT APPROXIMATELY 80 MPH, THERE WAS A VIBRATION COMING FROM THE DRIVER SIDE AND THERE WAS FLUID LEAKING FROM THE VEHICLE. THE CONTACT NOTICED THAT THE TRANSMISSION TRANSFER CASE WAS FRACTURED AND FLUID WAS LEAKING. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
TL* THE CONTACT OWNS A 1993 FORD AEROSTAR. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 169,000.
BACKED INTO PINE TREE IN DRIVEWAY. SHATTERED PLASTIC BUMPER COVER. CAN NOT REPLACE BUMPER COVER BECAUSE FORD SAYS OBSOLETE. ALSO NO AFTER MARKET BUMPER CAN BE FOUND FOR THIS MODEL. THIS BUMPER PROTECTS NO ONE. *JS FORD WON'T EVEN GIVE ME THE FORD PART NUMBER. ITS A CARGO VAN. OTHER MODEL COVERS CAN BE BOUGHT FROM AFTER MARKET SELLERS BUT NOT THE CARGO VAN. ONLY PLACE TO GET ONE IS JUNK YARDS IF YOU ARE GET LUCKY. MOST OF THEIR COVERS ARE BUSTED ALSO. A CAR IS A HAZARD WITHOUT A BUMPER. *JS
TL*THE CONTACT OWNS A 1993 FORD AEROSTAR. THE CONTACT STATED THAT HE NOTICED ELECTRICAL PROBLEMS. THERE WAS A CLICKING SOUND AND HE COULD FEEL A PULSATION IN THE DASHBOARD; THERE WERE ALSO ELECTRICAL SHORTAGES. HE CALLED THE DEALERSHIP ABOUT RECALL 99V029000 AND WAS TOLD THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. HE ALSO CONSULTED THE MANUFACTURER AND IT WAS CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE CURRENT MILEAGE WAS 144,705. THE FAILURE MILEAGE WAS APPROXIMATELY 144,670. UPDATED 02/22/11
TL*THE CONTACT OWNS A 1993 FORD AEROSTAR. THE CONTACT STATED THAT HIS VEHICLE WAS PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR; THEREFORE, CREATING A SHORT CIRCUIT AND ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE. ON NUMEROUS OCCASIONS, HE NOTICED THAT THE SWITCH MODULE MELTED AND THE INSTRUMENT CONTROL PANEL LIGHTING WAS INOPERATIVE. AS A RESULT, THE RISK OF A SEVERE FIRE INCREASED. THE MANUFACTURER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 99V029000 (ELECTRICAL SYSTEM:IGNITION:SWITCH); THEREFORE, THEY WOULD NO
1993 Ford Aerostar questions
Does the 1993 Ford Aerostar have any recalls?
Yes. NHTSA lists 2 safety recalls for the 1993 Ford Aerostar: Electrical System:Ignition:Switch; Power Train:Transfer Case (4-Wheel Drive). Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 1993 Ford Aerostar?
Based on 374 owner complaints filed with NHTSA, the most-reported problem areas are Electrical System (110), Service Brakes, Hydraulic (77), Power Train (75).
How do I check if a recall on my 1993 Ford Aerostar has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.