2002 Damon Intruder Recalls, Problems & Safety Rating

2002 Damon Intruder recalls

Most common 2002 Damon Intruder problems

Problem areas named in the 5 complaints owners filed with NHTSA.

Problem area	Reports
Structure	2
Service Brakes, Hydraulic	2
Power Train	1
Equipment	1
Visibility	1
Fuel/Propulsion System	1

What owners report

2017-07-26, Fuel/Propulsion System
I PURCHASED THIS RV IN DEC 2016 I HAVE BEEN ON A COUPLE SMALL TRIPS THEN WENT ON A 1000 MILE TRIP AND FOUND THAT A SWAY BAR BOLT WAS MISSING AND THE PROPANE TANK WAS RUBBING ON THE REAR LEAF SPRINGS. THE SPACE BETWEEN THE PROPANE TANK AND LEAF SPRINGS IS TO CLOSE. I HAVE TAKEN A PHOTO OF THE ISSUE. I HAVE LOOKED FOR A RECALL BUT I THINK BECAUSE OF THE AGE IT HAS DROPPED OFF. THERE ARE MORE VEHICLES OUT THERE THAT ARE LIKE MINE AND I WOULD BE AFRAID IF SOMETHING WOULD HAPPEN TO SOMEONE ELSE.I AM A RETIRED FIREFIGHTER AND HAVE BEEN ON A PROPANE TANK EXPLOSION ENVOLVING AN RV. AND IT'S NOT A GOOD FEELING TO SEE THIS. I HAVE CONTACTED THOR MOTOR COACH AND FORD BOTH ARE UNAWARE OF ANY RECALL IN

2011-05-05, Service Brakes, Hydraulic
I HAD A SAFETY RECALL # 50401C DONE ON 05/09/2006 TO REPLACE ALL 4 CALIPERS BECAUSE THEY MIGHT HANG UP AND CAUSE BRAKE OVERHEATING AND MAYBE A ACCIDENT. AT THAT TIME THERE WAS NO DAMAGE AND NO WORN OF CRACKED PARTS. I WAS ASKED TO RETURN AGAIN FOR RECALL # 51101C TO AGAIN REPLACE ALL 4 CALIPERS TO THE LATEST STYLE FOR THE SAME REASON. THIS TIME 3 OF THE 4 CALIPERS ON THE MOTORHOME WERE DEEMED NOT USABLE BECAUSE OF CRACKS BUT THE WORK HORSE CORP. WON'T PAY FOR NEW ROTORS. I THINK THIS DAMAGE IS THEIR PROBLEM AND NOT MINE. PLEASE ADVISE.

2010-03-30, Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2002 DAMON INTRUDER RV. WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS AN UNUSUAL SMELL EMITTING FORM THE BRAKING SYSTEM. THE VEHICLE BEGAN DRAGGING AND WAS HESITANT TO ACCELERATE. THE VEHICLE WAS MOVED OFF OF THE ROAD. ONCE THE VEHICLE COOLED OFF FOR SEVERAL MINUTES, IT BEGAN OPERATING NORMALLY. THE CONTACT WAS ADVISED THAT THERE WAS A RECALL ON THE BRAKING SYSTEM; HOWEVER, THE REMEDY WAS NOT AVAILABLE (NHTSA CAMPAIGN ID NUMBER 09V225000- SERVICE BRAKES, HYDRAULIC). THE VEHICLE HAD NOT BEEN REPAIRED BECAUSE THE RECALL REMEDY WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 21,000.

2003-10-06, Structure
LEFT TOP CORNER WINDSHIELD SEAL FAILED, AND WAS LEAKING A LOT OF WATER. (2002 DAMON INTRUDER 369)*AK THE WINDSHIELD CAME OUT AT THE TOP LEFT HAND CORNER AND CAUSED WATER TO ENTER THE RV. THE DEALER INDICATED THAT THEY DIDN'T THINK IT WOULD STAY IN PLACE BECAUSE OF STRUCTURAL CONDITIONS THAT CAUSED THE SEAL NOT TO HOLD. *NLM

2003-01-02, Power Train
CONSUMER HAD DIFFICULTY CHECKING TRANSMISSION FLUID. THE DEALER HAD ATTEMPTED TO REPAIR THE VEHICLE 3 TIMES UNSUCCESSFULLY. *TS *AK THERE WAS A RATTLE NOISE, THE BATHROOM WAS OUT OF LINE, THE DOOR /EXIT DOOR DIDN'T STAY CLOSED, THE TANK LEAKED, THE WINDSHIELD WIPER WAS INOPERATIVE, AND THE ANTENNA WAS INOPERATIVE. SCC

2002 Damon Intruder questions

Does the 2002 Damon Intruder have any recalls?

Yes. NHTSA lists 3 safety recalls for the 2002 Damon Intruder: Service Brakes, Hydraulic; Equipment:Recreational Vehicle/Trailer; Service Brakes, Hydraulic:Brake Fluid Low Warning: Lamp. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2002 Damon Intruder?

Based on 5 owner complaints filed with NHTSA, the most-reported problem areas are Structure (2), Service Brakes, Hydraulic (2), Power Train (1).

How do I check if a recall on my 2002 Damon Intruder has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.