CarRecallWatchThe 2012 BMW R1200 GS has 1 safety recall on file with NHTSA.
Owners have filed 10 complaints with NHTSA, including 1 injury.
The most-reported problem area is Fuel/Propulsion System (4 reports).
2012 BMW R1200 GS recalls
Fuel Pump May Crack and Leak, Creating Fire Risk
The fuel pump, and the auxiliary fuel pump on certain models, can crack and leak fuel while the motorcycle is being ridden.
Most common 2012 BMW R1200 GS problems
Problem areas named in the 10 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Fuel/Propulsion System | 4 |
| Power Train | 3 |
| Engine | 2 |
| Suspension | 1 |
| Structure | 1 |
| Equipment Adaptive/Mobility | 1 |
| Fuel System, Gasoline | 1 |
What owners report
The contact owns a 2012 BMW R 1200 GS. The contact stated while driving at various speeds, the contact noticed in the rear-view mirror that there was fluid leaking from the motorcycle onto the roadway. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the flange for the fuel pump fractured and needed to be replaced. The vehicle was not repaired. The vehicle was not drivable. The contact referenced NHTSA Campaign Number: 21V060000 (Fuel System, Gasoline) as a possible solution to the failure however, the VIN was not included. The manufacturer was notified of the failure. The failure mileage was approximately 100,000.
SEVERAL TIMES THE BIKE THREW AN ERROR MESSAGE ABOUT "ENGINE CONTROLLER FAULT" AND LOST POWER, GOING INTO "LIMP-HOME" MODE. ALL OCCURRENCES WERE WHILE THE BIKE WAS BEING OPERATED AT HIGHWAY SPEEDS, SOMETIMES IN THE MIDDLE OF A CORNER. THE BIKE WAS UNRIDEABLE IN LIMP-HOME MODE SO WAS NAVIGATED OUT OF TRAFFIC AND SHUT DOWN AT ROADSIDE. AFTER A BRIEF WAIT THE BIKE WAS STARTED AGAIN AND RAN NORMALLY.THE ISSUE WAS REPORTED TO THE DEALER AT THE 12K SERVICE AND AN UPDATED FLASH WAS APPLIED TO THE ECU, BUT THE BIKE HAS SINCE NOT BEEN RIDDEN SO I DO NOT KNOW IF THE ISSUE HAS BEEN RESOLVED. I AM UPLOADING WITH THIS FILING A PDF FILE CONTAINING THE RESULTS OF AN OBD SCAN I RAN ON THE VEHICLE BEFORE
FUEL PUMP FAILURE: ON OR ABOUT SEPTEMBER 5TH, 2019 I WAS RIDING MY BMW R 1200GS ON HIGHWAY US-60 IN ARIZONA EAST OF MESA ARIZONA. I PULLED OVER AT US-60 AND IDAHO ROAD TO CHECK MY CELL PHONE AND AS I LOOKED DOWN I COULD SEE A PUDDLE OF GAS LEAKING OUT OF THE UNDERSIDE OF MY BMW. I PROMPTLY TURNED THE BIKE OFF AND LOOKED TO SEE IF THERE WAS ANY OBVIOUS DAMAGE. THERE WAS NO VISIBLE DAMAGE TO THE NAKED EYE. I PUSHED MY BIKE TO AS SAFE PLACE ( CHEVRON GAS STATION AND PARKED IT ON THE SIDE OF THE STATION. THEN HAD A FRIEND WITH A TRAILER AND PICKUP DRIVE OUT TO MEET ME AND PUT BIKE ON TRAILER AND TOOK HOME. TOOK BIKE HOME TO MY GARAGE, LOOKED FOR WAY TO FIX LEAK. IT WAS BEYOND MY CAPABILIT
SPRAY LEAK FROM FUEL PUMP, QUICK CONNECTOR ON THE FLANGE BROKE AND HAD A STRONG SPRAY OF FUEL LEAKING ON THE HOT ENGINE AND MY CLOTHES, THIS HAPPEND ON THE FREEWAY WHILE RIDING AT 70MPH. THERE IS A RECALL ON THIS BIKES UP TO 2011, MINE IS 2012.
FUEL PUMP FLANGE HAS A VERTICAL CRACK ON THE INSIDE OF THE BOSS, WHERE THE THREADS ARE.
2012 BMW R1200 GS questions
Does the 2012 BMW R1200 GS have any recalls?
Yes. NHTSA lists 1 safety recall for the 2012 BMW R1200 GS: Fuel Pump May Crack and Leak, Creating Fire Risk. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2012 BMW R1200 GS?
Based on 10 owner complaints filed with NHTSA, the most-reported problem areas are Fuel/Propulsion System (4), Power Train (3), Engine (2).
How do I check if a recall on my 2012 BMW R1200 GS has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.