CarRecallWatchThe 1991 Volkswagen Vanagon has 2 safety recalls on file with NHTSA.
Owners have filed 9 complaints with NHTSA, including 2 fires.
The most-reported problem area is Engine And Engine Cooling (3 reports).
1991 Volkswagen Vanagon recalls
Most common 1991 Volkswagen Vanagon problems
Problem areas named in the 9 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Engine And Engine Cooling | 3 |
| Electrical System | 2 |
| Equipment | 2 |
| Tires | 2 |
What owners report
TL* THE CONTACT OWNS A 1988 VOLKSWAGEN VANAGON (N/A) EQUIPPED WITH KUMHO RADIAL 857 TIRES, SIZE: 185/75R14C. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE REAR PASSENGER TIRE TREAD BECAME DETACHED, CAUSING A BLOW OUT. THE VEHICLE WAS TOWED TO A LOCAL TIRE SHOP WHERE THE MECHANIC ADVISED THAT THE BELT IN THE TIRE BECAME FRACTURED AND CAUSED THE TREAD TO BECOME DETACHED. THE DEALER REPLACED THE FAILED TIRE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE OF THE TIRE WAS 7,100. THE VEHICLE FAILURE MILEAGE WAS 110,615. UPDATED 11-25-13 *BF PICTURE RECEIVED. 12/04/13
MY HANKOOK RA08 195R14C TIRE SIDE WALL BLEW OUT AS I WAS TRAVELING SOUTH BOUND ON I-110 AT APPROX. 65 MPH. THERE WAS NO INDICATION THAT THE EVENT WAS TO HAPPEN AS THE TIRE DID NOT SEEM DEFLATED WHEN I GET INTO THE VEHICLE IN THE MORNING. I TOOK A PICTURE OF THE BLEWOUT TIRE, AND I STILL HAVE THE TIRE, AND I SUSPECT IT WAS THE CASE OF A MANUFACTURE DEFECT BASED ON THE CLEAN TEARS ON THE SIDE WALL OF THE TIRE. *TR
TL* THE CONTACT OWNS A 1991 VOLKSWAGEN VANAGON. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 93V175000 (EQUIPMENT:ELECTRICAL:AIR CONDITIONER) AND WAS REPAIRED. AFTER THE REPAIR THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WHEN HE DROVE OVER A BUMP IN THE ROAD AND THE AIR CONDITIONING UNIT DETACHED FROM THE CEILING OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 189,000.
SAME AS MENTIONED IN MANUFACTURER'S RECALL 6836 AFFECTING AIR CONDITIONER:HOSE:DUCT:AIR. *AK
THE CAR WAS LEAKING ANTI-FREEZE DUE TO CORRODED ENGINE. ENGINE HEAD GASKET HAS BLOWN 2 TIMES AND IS BEING REPLACED FOR THE 3RD TIME.
1991 Volkswagen Vanagon questions
Does the 1991 Volkswagen Vanagon have any recalls?
Yes. NHTSA lists 2 safety recalls for the 1991 Volkswagen Vanagon: Equipment:Appliance:Air Conditioner; Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 1991 Volkswagen Vanagon?
Based on 9 owner complaints filed with NHTSA, the most-reported problem areas are Engine And Engine Cooling (3), Electrical System (2), Equipment (2).
How do I check if a recall on my 1991 Volkswagen Vanagon has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.