2006 Toyota Tacoma Recalls, Problems & Safety Rating

2006 Toyota Tacoma recalls

Most common 2006 Toyota Tacoma problems

Problem areas named in the 782 complaints owners filed with NHTSA.

Problem area	Reports
Structure	249
Suspension	154
Vehicle Speed Control	148
Air Bags	77
Power Train	57
Unknown Or Other	47
Steering	40
Engine And Engine Cooling	27
Service Brakes, Hydraulic	26
Electrical System	25

What owners report

2026-04-22, Structure
I received a Toyota recall notification in Dec 2015 for a frame rust inspection, RO Number 307016. I have since noticed fairly major frame rust, with a long 2-inch by 7-inch opening on the inside of the frame below the driver-side seat. I took the vehicle to Toyota on 20 APR 2026 for a leaf spring recall #302870. I asked them to take a look and was told the recall 307016 had expired. The original recall inspection for rust either failed to identify it or the inspector was inadequate at identifying it.

2026-02-22, Suspension
Voss Toyota would not perform the recall of new leaf springs that has not been completed on my truck. The frame is rusty and they will not touch my truck. There should be an existing recall or customer satisfaction program on the frame of this truck that needs done as well.

2025-11-28, Structure
I took my 2006 Toyota Tacoma ext cab 4x4 v6 to have diagnostic run on it . "EXACT PERFORMANCE " Johnson drive . KCK The differential was shot . However , that was not the final . They did not do full diagnostic . They informed me that my frame was rotted and rusted through and would not last till spring and was a safety hazard. That was Dec. 2024 . The truck has been parked since . Ive had no transportation and can not run right out and buy another truck . I am also not willing to give up the truck either . I have put a lot of hard earned money into this truck believing it to last forever . The motor and train are sound . I do not want to junk the truck . Please , tell me what I can do . Ye

2025-05-09, Structure
The frame of my 2006 Toyota Tacoma (VIN: [XXX] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past Toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in for the service. The frame now shows advanced rust and structural weakness, which puts my safety and the safety of others at risk. I am concerned that the recall program was not adequately communicated or tracked, and I am requesting that the NHTSA review this issue for potential reopening or expansion of coverage for affected vehicles like mine. The vehicle is available for inspection if needed. T

2025-04-11, Structure
The contact owns a 2006 Toyota Tacoma. The contact stated while driving at an undisclosed speed, the contact heard a loud noise coming from the rear of the vehicle with no warning light illuminated. The contact stated that while the vehicle was parked, the contact noticed that the rear subframe of the vehicle was fractured. The vehicle was towed to an independent mechanic, where it was diagnosed that the rear subframe of the vehicle failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 230,000.

2006 Toyota Tacoma questions

Does the 2006 Toyota Tacoma have any recalls?

Yes. NHTSA lists 11 safety recalls for the 2006 Toyota Tacoma: Aftermarket Seat Heaters May Short Circuit and Cause Fire; Seats:Front Assembly:Seat Heater/Cooler; Suspension:Rear:Springs:Leaf Spring Assembly:Leaf; Seat Belts; Air Bags:Frontal. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2006 Toyota Tacoma?

Based on 782 owner complaints filed with NHTSA, the most-reported problem areas are Structure (249), Suspension (154), Vehicle Speed Control (148).

How do I check if a recall on my 2006 Toyota Tacoma has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.