2003 Pontiac Sunfire Recalls, Problems & Safety Rating

2003 Pontiac Sunfire recalls

Most common 2003 Pontiac Sunfire problems

Problem areas named in the 72 complaints owners filed with NHTSA.

Problem area	Reports
Exterior Lighting	28
Electrical System	27
Engine And Engine Cooling	8
Service Brakes, Hydraulic	6
Air Bags	6
Fuel System, Gasoline	5
Power Train	4
Visibility	4
Structure	3
Equipment	3

What owners report

2014-09-03, Electrical System
EVERY TIME I LET MY CAR SIT FOR 2 HOURS OR MORE, I START IT UP AND THE BELT ON THE TENSIONER SQUEAK FOR 15 SECONDS. ALSO THE BATTERY LIGHT COMES ON AND THE RIM FLUCTUATE BETWEEN 1,000 AND 2,000. WHEN I DRIVE IT THE BATTERY LIGHT WILL CONTINUE TO STAY ON BUT EVERY TIME THE AIR BAG LIGHT TURNS ON AND I'M ACCELERATING THE ENGINE WILL NOT SHIFT, THE RPMS WILL REV UP TO RED LINE IF PUSHED THAT FAR, EVENTUALLY THE LIGHT FOR AIRBAG AND BATTERY WILL SHUT OFF AND IT WILL SHIFT. SOMETIMES WHEN I HIT THE GAS PEDAL WHILE THIS IS DOING THIS AT NIGHT, MY DASHBOARD AS WELL AS RADIO LIGHTS WILL SHUT OFF UNTIL RPMS GO DOWN TO 2,000. *TR

2014-08-19, Engine
TL* THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A RATTLING NOISE FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TIMING CHAIN SEPARATED AND CAUSED THE TENSIONER AND VALVE TO FAIL. THE TIMING CHAIN VALVE AND TENSIONER WERE REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 98,000.

2014-07-07, Electrical System
I WAS DRIVING HOME FROM VERNON DOWN'S CASINO AND WAS MAKING A RIGHT AND WAS ABOUT TO SWITCH INTO THIRD GEAR THE RPM'S WHERE 3000 AND THE ENGINE JUST DIED ........ MAUGERI''S AUTO ON ALBANY AND BLEEKER ST. TOWED MY CAR TO HIS SHOP FIXED THE STEERING COLUMN AS A RESULT OF THE ENGINE DIEING THE WINDOW'S WONT ROLL UP AND THE INTERIOR JUST GOT SOAKED IN WET IN THE RAIN AFTER ON THE DATE OF 7/714 PAID ALMOST A GRAND FOR TOWING AND STEERING COLUMN IN THE VEHICLE . I AM A RECIPIENT OF THE TRAUMATIC BRAIN INJURY PROGRAM AND USE THE VEHICLE TO AND FROM MY STRUCTURED DAY AS WELL AS MY NEUROLOGIST AS WELL AS MY HEMATOLOGIST WHO'S OFFICES ARE 57 MILES AWAY FROM MY HOUSE IT IS GOING TO BE VERY UNCOMFORT

2014-06-15, Steering
BOUGHT A 2003 PONTIAC SUNFIRE FROM A DEALERSHIP 5 MONTHS AGO. I TOLD THE OWNER/SALESMAN I WANTED A SAFE 1ST CAR FOR MY KID. MY KID AND SOME FRIENDS WERE DRIVING,IT WAS RAINING AND THE BACK TIRES STARTED TO SLIDE,MY KID REGAINED CONTROL OF THE CAR BRIEFLY AND SAID AFTER A FEW MINUTES THE STEERING LOCKED UP AND THEY ENDED UP IN A SPIN. THE CAR HIT AN OBJECT ON THE PASSENGER SIDE,SPUN AROUND AND HIT ANOTHER ON THE DRIVERS SIDE,THEN BOUNCED OFF THAT AND LANDED ACROSS A DEEP DITCH WHERE IT WAS HIT AGAIN IN THE REAR WHEN STOPPING. NO STEERING. NO BRAKES. THE ENGINE WAS STILL GOING EVEN THOUGH THE FRONT END OF THE CAR WAS WEDGED INTO THE EDGE OF THE PAVEMENT AND THE EMBANKMENT OF THE DITCH. BY THE

2014-03-03, Fuel/Propulsion System
TL* THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL FILTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT DID NOT RECTIFY THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 130,000. *TR

2003 Pontiac Sunfire questions

Does the 2003 Pontiac Sunfire have any recalls?

Yes. NHTSA lists 1 safety recall for the 2003 Pontiac Sunfire: Exterior Lighting:Turn Signal. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2003 Pontiac Sunfire?

Based on 72 owner complaints filed with NHTSA, the most-reported problem areas are Exterior Lighting (28), Electrical System (27), Engine And Engine Cooling (8).

How do I check if a recall on my 2003 Pontiac Sunfire has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.