2005 Kia RIO Recalls, Problems & Safety Rating

2005 Kia RIO recalls

Most common 2005 Kia RIO problems

Problem areas named in the 37 complaints owners filed with NHTSA.

Problem area	Reports
Engine And Engine Cooling	12
Engine	5
Air Bags	4
Seat Belts	4
Electrical System	4
Vehicle Speed Control	3
Power Train	3
Steering	3
Structure	2
Fuel System, Other	1

What owners report

2026-10-05, Unknown Or Other
On [XXX], while driving my 2005 Kia Rio northbound on [XXX] across the [XXX], I was coming from a meeting in Louisville, Kentucky, and heading toward Jeffersonville, Indiana. While I was driving, the hood (bonnet) of my vehicle suddenly and unexpectedly flipped up and slammed into the windshield. The hood struck the windshield with such force that it completely shattered the windshield and became lodged against it, completely obstructing my forward view. The impact was also severe enough to bend and break the hood at multiple points around its hinges. I have never experienced or seen anything like this before. Despite having my forward view completely obstructed, I was able to use my side

2020-11-13, Air Bags
I WAS DRIVING ON PUBLIC STREET LOSS CONTROL DUE TO A POT HOLE IN THE STREET THE CAR LOST CONTROL FLIPPING SLIDING THEN FLIP UP RIGHT TILL IT CAME TO A STOP ON APT WALL THEN WHEN IT WAS ALL OVER AND DONE THE AIRBAG DEPLOYED GO OFF ON MY ARM RIGHT ARM GIVING ME SECOND TO THIRD DEGREE BURNS THE PURPOSE OF THE AIR BAG ? I HAVE BROKEN BACK CAR WAS TOTALED NOW I GOT CHRONIC PAIN EVERYDAY I LOST MY CAR AM LIMITED ON MOBILEBILITY WAS GOING GET SCREWS PLACED ON MY BACK AND UN ABLE TO SET WALK OR STAND DO TO CHRONIC PAIN

2016-01-19, Seat Belts
TL* THE CONTACT OWNS A 2005 KIA RIO. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING LIGHTS RANDOMLY FLASHED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V244000 (AIR BAGS); HOWEVER, THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION. THE VEHICLE WAS TO BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

2016-01-08, Electrical System
WHEN THE CAR IS EXPOSED TO MOISTURE, EITHER FROM UNDERNEATH BY DRIVING THROUGH A SMALL PUDDLE OR FROM ABOVE IN A RAINSTORM, THE ENGINE COMPARTMENT GETS WET AND CAUSES THE SERPENTINE BELT TO SLIP. THIS RESULTS IN SUDDEN LOSS OF POWER STEERING AND ALTERNATOR FAILURE, WHICH CAN LEAD TO THE CAR'S POWER CUTTING OUT IN THE MIDDLE OF THE ROAD. THIS IS AN OBVIOUS DRIVING HAZARD, BUT I AM TOLD THAT THIS IS A COMMON ISSUE DUE TO THE CONSTRUCTION OF THE ENGINE COMPARTMENT IN KIA VEHICLES RATHER THAN A PRECIPITATING MECHANICAL FAILURE CAUSING IT.

2015-09-24, Engine
TL* THE CONTACT OWNS A 2005 KIA RIO. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD TO A COMPLETE STOP. THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT FRACTURED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT ALSO STATED THAT THE VEHICLE WAS INSPECTED AND TAGGED WITH LICENSE PLATES ONE HOUR BEFORE THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 65,125.

2005 Kia RIO questions

Does the 2005 Kia RIO have any recalls?

Yes. NHTSA lists 1 safety recall for the 2005 Kia RIO: Child Seat. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2005 Kia RIO?

Based on 37 owner complaints filed with NHTSA, the most-reported problem areas are Engine And Engine Cooling (12), Engine (5), Air Bags (4).

How do I check if a recall on my 2005 Kia RIO has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.