2009 Kawasaki Vulcan Recalls, Problems & Safety Rating

2009 Kawasaki Vulcan recalls

Most common 2009 Kawasaki Vulcan problems

Problem areas named in the 5 complaints owners filed with NHTSA.

Problem area	Reports
Power Train	2
Engine And Engine Cooling	1
Engine	1
Service Brakes, Hydraulic	1

What owners report

2013-09-09, Service Brakes, Hydraulic
2009 KAWASAKI VULCAN. CONSUMER WRITES IN REGARDS TO ENGINE STALLING RECALL NOTICE. *SMD THE CONSUMER STATED HE TOOK THE MOTORCYCLE BACK TO THE DEALER SEVERAL TIMES, DUE TO THE STALLING ISSUE. FINALLY, WHILE RIDING THE BIKE ONE DAY, IT STALLED AGAIN. ONLY THIS TIME, THE CONSUMER HAD AN ACCIDENT, AND WAS THROWN OFF THE MOTORCYCLE. THE CONSUMER SUFFERED INJURIES. RECALL# 10V507000.

2013-07-29, Engine
TL* THE CONTACT OWNS A 2009 KAWASAKI VULCAN 1700 VOYAGER MOTORCYCLE. THE CONTACT STATED THAT WHILE RIDING THE BIKE, THERE WAS A LOUD WHISTLING NOISE EMITTED CONTINUOUSLY. THE BIKE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE ENGINE UNDER DRIVE PULLEY AND BELT WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 1,000. UPDATED 09/05/13*LJ THE CONSUMER WAS INFORMED THE DRIVE BELT, ENGINE PULLEY AND REAR TIRE PULLEY WERE BAD, WHICH WAS CAUSED BY DIRT, AND THE MANUFACTURER REFUSED TO COVER THE REPAIRS. UPDATED 09/05/13

2011-09-16, Power Train
TL* THE CONTACT OWNS A 2009 KAWASAKI VULCAN. THE CONTACT STATED THAT THE VEHICLE WOULD BECOME STUCK IN THIRD AND FIFTH GEARS, CAUSING DIFFICULTY WHEN ATTEMPTING TO BRAKE. THE CONTACT WOULD HAVE TO POP THE VEHICLE OUT OF GEAR AND RE-ENGAGE. THE DEALER ADJUSTED THE CLUTCH IN AN ATTEMPT TO CORRECT THE FAILURE BUT TO NO AVAIL. THE DEALER WAS MADE UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS 1 AND THE CURRENT MILEAGE WAS 400.

2010-11-24, Power Train
TL*THE CONTACT OWNS A 2009 KAWASAKI VULCAN. WHILE THE VEHICLE WAS BEING SERVICED, THE CONTACT WAS INFORMED THAT THE DRIVE BELT HAD A CUT IN IT LENGTH-WISE. THE REASON FOR THE CUT WAS THAT THERE WAS NO PROTECTIVE SHIELD FOR THE TOP PORTION OF THE DRIVE BELT. THE CONTACT STATED THAT A ROCK LODGED IN THE FRONT HOUSING TRAPPED THE ROCK CAUSING IT TO CUT THE BELT. THE DEALER STATED THAT THE FAILURE WAS A DESIGN FLAT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 6,100.

2010-11-21, Engine And Engine Cooling
THE KAWASAKI VULCAN 1700 VOYAGER - 2009 GENERATES EXCESSIVE HEAT. I RECEIVED SECOND DEGREE BURNS FROM IT. KAWASAKI ADMITTED THERE WAS A PROBLEM AND PROVIDED A HEAT SHIELD KIT THAT DID NOTHING TO REDUCE THE HEAT BUT MOVED IT TO THE PASSENGER-RIDER. KAWASAKI HAS DONE NOTHING TO THIS MODEL YEAR MOTORCYCLE TO FIX THE HEAT PROBLEM. RIDERS OF THIS BIKE STILL COMPLAIN ABOUT THE HEAT, SEE MOST ANY FORUM DISCUSSING THIS MOTORCYCLE FOR MANY COMPLAINTS AND SPECIFICALLY KAWASAKI'S UNWILLINGNESS TO ADMIT THAT THEY CAN NOT OR WILL NOT FIX THE PROBLEM. IN THE 2010 MODEL ADVERTISING CAMPAIGN THEY CLAIM TO HAVE FIXED IT, YET THE PROBLEM REMAINS BASED ON THE FORUM CONVERSATIONS. WHEN COMPLAINTS ARE MA

2009 Kawasaki Vulcan questions

Does the 2009 Kawasaki Vulcan have any recalls?

Yes. NHTSA lists 1 safety recall for the 2009 Kawasaki Vulcan: Service Brakes, Hydraulic:Pedals And Linkages. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2009 Kawasaki Vulcan?

Based on 5 owner complaints filed with NHTSA, the most-reported problem areas are Power Train (2), Engine And Engine Cooling (1), Engine (1).

How do I check if a recall on my 2009 Kawasaki Vulcan has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.