2005 GMC Sierra Recalls, Problems & Safety Rating

2005 GMC Sierra recalls

Most common 2005 GMC Sierra problems

Problem areas named in the 117 complaints owners filed with NHTSA.

Problem area	Reports
Service Brakes	27
Electrical System	23
Steering	13
Power Train	11
Service Brakes, Hydraulic	10
Engine And Engine Cooling	9
Suspension	9
Engine	8
Structure	7
Vehicle Speed Control	6

What owners report

2015-12-06, Service Brakes
ON 11-30-2015 I LOST THE BRAKE SYSTEM WHILE DRIVING ON A CITY STREET. UPON INSPECTION I FOUND A RUPTURED BRAKE LINE FROM THE PRIMARY SIDE OF THE MASTER CYLINDER. THE BRAKE LINE HAD FAILED DUE TO CORROSION. INSPECTING OTHER BRAKE LINES, I FOUND OTHERS THAT HAD CORROSION WHERE PLASTIC CLIPS WERE USED TO LOCATE LINES. I HAVE OWNED THIS TRUCK SINCE NEW AND HAVE CARED FOR IT METICULOUSLY. THE TRUCK HAS 66,00 MILES ON IT. I HAVE NEVER OWNED ANY VEHICLE THAT HAD IT BRAKE LINES RUST THROUGH LIKE THIS. A MAJOR CATASTROPHE TO ME AND MY FAMILY WAS AVERTED BY PULLING OVER AT THE FIRST SIGN OF FAILURE. GM SHOULD BE HELD LIABLE FOR EVERY VEHICLE IT MANUFACTURED WITH POOR QUALITY MATERIALS THAT CAN

2015-10-15, Fuel/Propulsion System
ISSUES WITH EMISSIONS SWITCH. CHECK ENGINE LIGHT WILL NOT GO OFF. ALSO 3 AND 4TH GEAR ARE COMPLETELY GONE OUT. I DO NOT TOW OR HAVE HAD ANYTHING EVEN REMOTELY HEAVY IN THIS TRUCK. IT'S A 2005 GMC SIERRA WITH ONLY 78,480 MILES ON IT. I AM NOT THE ONLY ONE HAVING ISSUES WITH THIS 4 SPEED TRANSMISSION. IT IS NOT HEAVY DUTY ENOUGH FOR THIS SIZE TRUCK. GM NEEDS TO RECALL ALL OF THESE TRANSMISSIONS. WHEN IT FIRST STARTED SLIPPING I LOST ALL POWER GOING DOWN THE ROAD AT ABOUT 55MPH. THE VEHICLE THAT WAS BEHIND ME SLAMMED ON HIS BRAKES TO AVOID HITTING ME. THIS PROBLEM WITH THE TRANSMISSION IS GOING TO KILL SOMEONE.

2015-09-23, Service Brakes
VEHICLE WAS STOPPED. BRAKE PEDDLE WENT TO THE FLOORBOARD. NOT ABLE TO PUMP UP ANY PRESSURE. INVESTIGATION SHOWED BRAKE FLUID COMING FROM PERFORATED BRAKE LINE AT LEFT FRONT WHEEL. NO BRAKING ACTION AVAILABLE! APPEARS TO BE SOME TYPE OF CORROSIVE REACTION BETWEEN THE BRAKE LINE AND THE CLAMPS USED TO FASTEN THE LINE TO THE CHASSIS. NOTE: THIS VEHICLE HAS NEVER BEEN OPERATED IN SNOW OR ROAD SALT TO MY KNOWLEDGE.

2015-09-14, Service Brakes
BRAKE FAILURE DO TO RUSTED OUT LINES.A ONGOING PROBLEM THAT GM WILL NOT TAKE RESPONSIBILITY FOR THE POOR QUALITY OF THESE LINES PUTTING PEOPLE'S LIVES AT RISK.

2015-08-12, Engine
TL* THE CONTACT OWNS A 2005 GMC SIERRA. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE ENGINE SUDDENLY INCREASED IN SPEED TO APPROXIMATELY 10 MPH. THE CONTACT STATED THAT THE DISPLAY PANEL READ "REDUCED POWER MODE" AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED WITHOUT WARNING. THE VEHICLE WAS THEN TAKEN TO A DEALER WHERE THE THROTTLE BODY WIRE HARNESS, THE THROTTLE ACCELERATOR CONTROL MODULE, AND THE ACCELERATOR PEDAL ASSEMBLY WERE REPAIRED. THE REPAIR FA

2005 GMC Sierra questions

Does the 2005 GMC Sierra have any recalls?

Yes. NHTSA lists 9 safety recalls for the 2005 GMC Sierra: Air Bags:Frontal; Engine And Engine Cooling; Steering:Hydraulic Power Assist:Hose, Piping, And Connections; Parking Brake; Seat Belts:Rear/Other. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2005 GMC Sierra?

Based on 117 owner complaints filed with NHTSA, the most-reported problem areas are Service Brakes (27), Electrical System (23), Steering (13).

How do I check if a recall on my 2005 GMC Sierra has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.