2002 GMC Sierra 3500 Recalls, Problems & Safety Rating

2002 GMC Sierra 3500 recalls

Most common 2002 GMC Sierra 3500 problems

Problem areas named in the 20 complaints owners filed with NHTSA.

Problem area	Reports
Service Brakes	4
Suspension	3
Parking Brake	3
Service Brakes, Hydraulic	3
Fuel/Propulsion System	3
Fuel System, Gasoline	2
Tires	2
Air Bags	2
Fuel System, Diesel	2
Visibility	1

What owners report

2016-04-22, Engine
TL* THE CONTACT OWNS A 2002 GMC SIERRA 3500. WHILE OPERATING THE VEHICLE, THE ODOR OF FUEL WAS NOTICEABLE INSIDE THE CABIN. UPON INSPECTION, THE CONTACT DISCOVERED FUEL HAD LEAKED FROM THE VEHICLE ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL INJECTORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 120,000.

2015-10-30, Service Brakes
THIS TRUCK HAS THE SAME PROBLEMS AS THE 2007 MODEL. THE IGNITION SWITCH, PARKING BRAKE, AND FUEL LINES ALL HAVE ISSUES AS SIMILARLY DESCRIBED FOR THE 2007 MODEL. THE FUEL LINES ACTUALLY BROKE THROUGH CAUSING A LEAK OF THE DIESEL FUEL. THIS HAPPENED AFTER THE VEHICLE WAS DRIVEN A SHORT DISTANCE OF 15 MILES.

2015-06-30, Fuel/Propulsion System
WHILE DRIVING DOWN A VERY BUSY STREET, THE ENGINE DIED. I LOST ALL MY POWER STEERING AND BRAKE. I WAS VERY LUCKY THAT I WAS NOT ON A VERY BUSY HIGHWAY. I HAD IT TOWED TO HEDRICK'S CHEVROLET IN CLOVIS CA. IT TOOK 2 DAYS FOR THEM TO CHECK IT OUT. THEY SAID WHEN THEY WENT TO BRING IT IN TO THE SHOP IT STARTED UP AND THEY COULD NOT FIND ANYTHING WRONG WITH IT. I PICKED THE TRUCK UP AND THE NEXT DAY IT DID THE SAME THING AGAIN. I CALLED THE DEALER AND THEY TOLD ME TO PRESS THE PUMP ON THE TOP OF THE FILTER HOUSING UNTIL I COULD NO LONGER PRESS IT. I DID THAT AND IT STARTED UP. BE CAME VERY OBVIOUS THAT THEY WERE AWARE THAT THE FUEL FILTER HOUSING WAS CAUSING THE INJECTION SYSTEM TO LOSE S

2013-07-21, Service Brakes
SLOWING DOWN TO A RED TRAFFIC LIGHT AND BRAKE PEDAL WENT TO THE FLOOR. TRIED TO PUMP BRAKE PEDAL TO GET MORE PRESSURE BUT DID NOT WORK. DROVE OFF ONTO SHOULDER AND GOT IT SLOWED DOWN . DRIVE VERY SLOW WITH HAZARD LIGHTS ON TO GET IT BACK TO MY HOUSE. I WAS ONLY ABOUT A MILE AWAY. GOT HOME AND LOOKED UNDERNEATH TO FIND BRAKE FLUID ALL OVER LEFT REAR WHEELS, FUEL TANK, LEFT REAR SHOCK AND DRIVE AXLE. CONTINUED TO LOOK AT ALL BRAKE LINES AND ALL OF THEM WERE CORRODED BAD. GETTING PRICES ON HAVING ALL BRAKE LINES REPLACED. *TR

2013-02-11, Fuel System, Diesel
I FIRST NOTICED THAT THE ANTI-LOCK BRAKES WERE ACTIVATING AT SLOW SPEEDS ( 5-10 MPH ) UNDER DRY ROAD CONDITIONS. THIS WAS PRIOR TO BRAKE LINE INCIDENT ON 4-14-2012 BUT I AM NOT SURE OF EXACT DATE. I RESEARCHED THE ANTI-LOCK BRAKES AND FOUND NHTSA ID CAMPAIGN #05V379000 ACTION # PE05020 BUT THIS DID NOT INCLUDE MY HOME STATE OF KENTUCKY. HOWEVER, I HAVE BEEN WORKING IN OHIO SINCE THE PURCHASE OF SAID VEHICLE 10-17-2001 TO CURRENT DATE 2-11-2013. ON 4-14-2012 I WAS PREPARING TO TAKE MY BOAT TO FUEL IT . WHILE CHECKING THE TRAILER LIGHTS I STEPPED ON THE BRAKE PEDAL AND IT WENT STRAIGHT TO THE FLOOR. I FOUND THAT THE BRAKE LINE TO THE REAR WHEELS HAD BURST IN HALF AND WAS SEVERELY CORRODED. UP

2002 GMC Sierra 3500 questions

Does the 2002 GMC Sierra 3500 have any recalls?

Yes. NHTSA lists 2 safety recalls for the 2002 GMC Sierra 3500: Equipment Adaptive/Mobility; Interior Lighting. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2002 GMC Sierra 3500?

Based on 20 owner complaints filed with NHTSA, the most-reported problem areas are Service Brakes (4), Suspension (3), Parking Brake (3).

How do I check if a recall on my 2002 GMC Sierra 3500 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.