2002 Dodge RAM Van Recalls, Problems & Safety Rating

2002 Dodge RAM Van recalls

Most common 2002 Dodge RAM Van problems

Problem areas named in the 14 complaints owners filed with NHTSA.

Problem area	Reports
Structure	4
Electrical System	3
Steering	3
Engine And Engine Cooling	1
Visibility	1
Fuel System, Gasoline	1
Air Bags	1
Service Brakes, Hydraulic	1
Seats	1

What owners report

2015-02-10, Structure
TOOK VAN IN FOR INSPECTION AND WAS INFORMED THAT THE ENTIRE FRAME HAD RUST ISSUES. WAS TOLD THE FRONT FRAME WAS SO BAD I SHOULD JUST PARK IT AS THAT ANYTHING FROM THE RADIATOR TO THE ENGINE COULD JUST FALL OUT WITH ONE GOOD JOLT. DID A LITTLE RESEARCH AND FOUND THIS IS A COMMON PROBLEM WITH THESE VEHICLES AS WITH THE TOYOTA TRUCKS. THE BODY SHOP I TOOK IT TO SAID HE HAD 13 OF THEM THIS YEAR ALONE. I CRAWLED UNDER THERE AND THERE ARE LARGE AREAS OF FRAME THAT HAS JUST DISAPPEARED. EITHER POOR QUALITY STEEL OR IMPROPER RUST PREVENTION AT MANUFACTURE POINT COULD CAUSE THIS MUCH DAMAGE. COMPANY SHOULD BE MADE TO STEP UP AND REPLACE THE FRAMES. *TR

2014-08-28, Structure
ON 8/8/14, A LOUD BANGING SOUND OCCURRED WHEN GOING OVER BUMPS AND RAILROAD TRACKS WHILE DRIVING TO WORK. AT THAT TIME, STOPPED DRIVING VAN UNTIL WERE ABLE TO TAKE IT TO BETTENHAUSEN CHRYSLER JEEP IN TINLEY PARK, IL. ON 8/14/14. ON THE SAME DATE, WE WERE INFORMED THE VEHICLE WAS UNSAFE TO DRIVE. THE AREA AROUND THE SWAY BAR IS COMPLETELY RUSTED AWAY. THE OTHER AREAS OF THE FRAME SHOW RUST AND CORROSION WHICH WILL EVENTUALLY CAUSE THE STEERING MECHANISM TO FAIL MAKING THE VEHICLE VERY UNSAFE TO DRIVE. THE PROPER PROCEDURES WERE FOLLOWED TO DETERMINE IF CHRYSLER WOULD WARRANTY THE REPAIR OF THIS VEHICLE SINCE THEY HAVE EXPERIENCED THIS SAME PROBLEM WITH SOME OF THEIR OTHER VEHICLES. VAN

2011-06-22, Steering
TL* THE CONTACT OWNS A 2002 DODGE RAM 2500 VAN. THE CONTACT STATED WHILE DRIVING 2 MPH THE STEERING MOUNT BROKE FROM THE FRAME CAUSING A FAULTY WHEEL ALIGNMENT. THE VEHICLE WAS TOWED TO THE CONTACTS HOME. THE CONTACT INSPECTED THE FRAME AND NOTICE EXCESSIVE RUST ON THE FRAME. THE CONTACT CALLED THE MANUFACTURER REGARDING THE FRAME AND THE MANUFACTURER STATED THERE WERE NO RELATED RECALLS. THE CONTACT STATED IF HE WAS DRIVING ON THE HIGHWAY AT HIGH SPEEDS A CRASH COULD HAVE OCCURRED. THE FAILURE MILEAGE WAS 140,000.

2011-04-24, Structure
TOTAL LOSS OF STEERING DUE TO SEVERE FRAME ROT, WHICH LED TO THE DETACHMENT OF THE STEERING MOUNTS ON THE PASSENGER SIDE. LUCKILY IT HAPPENED AT A SLOW SPEED, AT THAT POINT HAD TO BE TOWED. HAD JUST EXITED HIGHWAY AT SPEEDS OF 65 MPH. I INFORMED DODGE OF THIS PROBLEM APPROXIMATELY 6 MONTHS AGO, BASICALLY THEY DON'T CARE. VEHICLE IS ONLY 8 YEARS OLD. IF IT IS HAPPENING TO MY VAN IT IS HAPPENING TO ALL VANS. ACTION NEEDS TO BE TAKEN QUICKLY IN ORDER TO SAVE LIVES. *TR

2010-05-10, Electrical System
ALL POWER STOPS TO VEHICLE, SHUTTING ENTIRE ENGINE, POWER BRAKES, STEERING OFF. IT OCCURS DAILY, WHIL EDRIVING ON ROADS/FREEWAYS, CREATING A SERIOUSLY HAZARDOUS SITUATION. DEALER PREVIOUSLY REPLACED THE POWER CONTROL MODULE. PROBLEM RECENTLY STARTED AGAIN. DEALER WANTS TO REPLACE THE PCM AGAIN AT HUGE COST, BUT CANNOT REPLICATE PROBLEM AND INST SURE THE PCM IS THE PROBLEM. MIGHT BE FAULTY WIRING, BUT DEALER CANNOT TELL. *TR

2002 Dodge RAM Van questions

Does the 2002 Dodge RAM Van have any recalls?

Yes. NHTSA lists 1 safety recall for the 2002 Dodge RAM Van: Power Train:Automatic Transmission:Lever And Linkage:Column Shift. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2002 Dodge RAM Van?

Based on 14 owner complaints filed with NHTSA, the most-reported problem areas are Structure (4), Electrical System (3), Steering (3).

How do I check if a recall on my 2002 Dodge RAM Van has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.