1994 Dodge Intrepid Recalls, Problems & Safety Rating

1994 Dodge Intrepid recalls

Most common 1994 Dodge Intrepid problems

Problem areas named in the 718 complaints owners filed with NHTSA.

Problem area	Reports
Power Train	173
Fuel System, Gasoline	117
Engine And Engine Cooling	92
Steering	86
Electrical System	74
Service Brakes, Hydraulic	68
Suspension	68
Structure	64
Exterior Lighting	59
Air Bags	45

What owners report

2021-03-18, Fuel/Propulsion System
I WAS DRIVING DOWN THE ROAD AND I STARTED SMELLING GAS. THE FUEL RAIL ON TOP OF THE ENGINE STARTED LEAKING BY THE PASSENGER SIDE FRONT INJECTOR. THERE WAS A RECALL ISSUED FOR THIS VEHICLE FOR THE SAME ISSUE THAT WAS SUPPOSED TO CORRECT IT AND THE RECALL WORK WAS DONE ACCORDING TO THE MANUFACTURER. YEARS LATER IT STARTED LEAKING AGAIN. APPARENTLY THE RECALL KIT DOES NOT FIX THE ISSUE, EVENTUALLY THE FUEL RAIL ON TOP OF THE ENGINE WILL EVENTUALLY START LEAKING AGAIN WHICH MAY RESULT IN AN ENGINE FIRE IF NOT FIXED. I HAD TO TAKE THE CAR TO A SHOP AND AM STILL WAITING FOR A REPAIR KIT FROM CHRYSLER.

2012-01-03, Fuel System, Gasoline
TL* THE CONTACT OWNS A 1994 DODGE INTREPID. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE SMELLED A STRONG ODOR OF GASOLINE FUEL. THE CONTACT EXAMINED THE VEHICLE HIMSELF AND NOTICED THAT THE FUEL LINES WERE LEAKING. THE CONTACT PATCHED THE LEAK HIMSELF ON SEVERAL OCCASIONS, BUT THE FAILURE CONTINUED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 120,000. UPDATED 01/25/12 *BF THE CONSUMER STATED THE FUEL LEAK WAS LOCATED ON BOTH SIDES OF THE CROSSOVER TUBE FOR THE FUEL RAILS. HE FIRST NOTICED THE ODOR OF FUEL ON NOVEMBER 13, 2088. BUT COULD NOT LOCATE THE SOURCE

2010-01-31, Steering
THE VEHICLE STARTED TO TURN ITSELF WHEN DRIVING AND COULD NOT BE CONTROLLED WHILE DRIVING. THIS LEAD TO US TAKING IT TO A TIRE SHOP AND WE WERE TOLD THE BUSHINGS ON THE RACK AND PINION AND THE BUSHINGS ON THE TIRE ROD WERE GONE OFF THE CAR. THE VEHICLE WAS NOT ABLE TO BE DRIVEN UNTIL THE BUSHINGS WERE REPAIRED BECAUSE THE LOSS OF CONTROL WAS SO BAD ON THE VEHICLE. THE FAILURE OF THE BUSHINGS CAUSED THE VEHICLE TO HAVE TO BE REPAIRED. WE ALMOST LOSS COMPLETE CONTROL OVER THE VEHICLE TWICE BEFORE WE FOUND OUT WHAT WAS CAUSING THE EXTREME PULL IN THE VEHICLE. THE VEHICLE WAS TAKEN TO MECHANIC AND THEY REPLACED THE RACK AND PINION BUSHINGS AND THE TIRE ROD BUSHINGS AND TIGHTENED THE TIRE ROD BOL

2009-10-07, Suspension
REAR SUSPENSION SUPPORT ARM ON DRIVER'S SIDE FATIGUED AND SEPARATED CAUSING LOSS OF CONTROL OF VEHICLE SUDDENLY WITHOUT WARNING. SUPPORT ARM APPEARS TO HAVE BEEN WEAKENED BY RUST CORROSION, APPEARS TO BE INADEQUATE CORROSION RESISTANCE. INSPECTION OF PASSENGER SIDE REAR SUSPENSION SUPPORT ARM APPEARS TO BE WEAKENED FROM RUST CORROSION AS WELL AND MOST LIKELY WILL FAIL FROM FATIGUE TOO. CONCERN THAT FAILURE OCCURS SUDDENLY WITHOUT WARNING AND WOULD RESULT IN LOSS OF CONTROL AND POSSIBLE LOSS OF LIFE. *TR

2008-12-29, Fuel System, Gasoline
TL*THE CONTACT OWNS A 1994 DODGE INTREPID. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT SMELLED A STRONG ODOR OF GASOLINE EMANATING FROM THE VEHICLE. IN ADDITION, THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. UPON FURTHER INSPECTION, THE CONTACT NOTICED FUEL LEAKING UNDER THE HOOD OF THE VEHICLE AND SMOKE. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 98V184000 (FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM). THE DEALER WOULD NOT ASSUME FINANCIAL RESPONSIBILITY FOR THE REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 170,000. UPDATED 2/2/09 *CN UPDATED 02/04/09. *JB

1994 Dodge Intrepid questions

Does the 1994 Dodge Intrepid have any recalls?

Yes. NHTSA lists 4 safety recalls for the 1994 Dodge Intrepid: Power Train:Automatic Transmission:Lever And Linkage:Floor Shift; Suspension:Front:Control Arm:Lower Arm; Fuel System, Gasoline:Fuel Injection System; Electrical System:Wiring. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 1994 Dodge Intrepid?

Based on 718 owner complaints filed with NHTSA, the most-reported problem areas are Power Train (173), Fuel System, Gasoline (117), Engine And Engine Cooling (92).

How do I check if a recall on my 1994 Dodge Intrepid has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.