1999 Chevrolet Suburban 2500 Recalls, Problems & Safety Rating

1999 Chevrolet Suburban 2500 recalls

No safety recalls on file for the 1999 Chevrolet Suburban 2500.

Most common 1999 Chevrolet Suburban 2500 problems

Problem areas named in the 12 complaints owners filed with NHTSA.

Problem area	Reports
Service Brakes, Hydraulic	4
Fuel System, Gasoline	2
Electrical System	2
Service Brakes	2
Fuel System, Diesel	1
Service Brakes, Electric	1
Structure	1

What owners report

2017-02-27, Service Brakes
TL* THE CONTACT OWNS A 1999 CHEVROLET SUBURBAN 2500. WHILE DRIVING 5 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO STOP. THE VEHICLE STRUCK A BUILDING. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 177,000. UPDATED 05/05/17*LJ *CN

2016-12-30, Fuel System, Gasoline
THE VEHICLE IN QUESTION IS A 1999 CHEVROLET SUBURBAN. THE GAS GAUGE READ ERRATICALLY AND INCORRECTLY FOR A NUMBER OF MONTHS. THEN THE ENGINE DIED IMMEDIATELY AFTER I PARKED THE VEHICLE ONE DAY AND FAILED TO RESTART. I DETERMINED THAT THE FUEL PUMP FUSE HAD BLOWN. A NEW FUSE LASTED 30 SECONDS BEFORE BLOWING IN ITS TURN. ON REMOVING THE GAS GAUGE SENDER/FUEL PUMP ASSEMBLY FROM THE GASOLINE TANK, I NOTICED THAT TWO OF THE WIRES WERE FUSED TOGETHER. SEPARATING THE WIRES TOOK SOME EFFORT AND REVEALED THAT THE INSULATION ON BOTH WIRES HAD COMPLETELY ABRADED WHERE THEY CONTACTED EACH OTHER SUCH THAT THE BARE WIRES INSIDE TOUCHED EACH OTHER AND SHORTED OUT THE CIRCUIT. THE INSULATION ON ONE

2012-11-03, Service Brakes
BRAKE LINES RUPTURE IN EMERGENCY SITUATIONS. THIRD INCIDENT OCCURRED ON NOV 2, 2012 AND ALMOST RESULTED IN A MAJOR ACCIDENT. FRONT BRAKE LINE WHICH RUNS ACROSS FRONT OF VEHICLE RUPTURED UPON BRAKING AND PEDAL WENT TO FLOOR. DELAYED STOPPING BECAUSE ONLY REAR BRAKES WERE USED TO STOP VEHICLE. THIS IS 3RD TIME BRAKE LINES FAILED ALL IN DIFFERENT AREAS OF UNDERCARRIAGE. TRUCK WILL NOT BE DRIVEN UNTIL ALL BRAKE LINES ARE REPLACED AND UNDERCARRIAGE IS APPLIED WITH AN ANTI -CORROSIVE, WHICH THIS WILL COST APPROXIMATELY $4,000 BECAUSE OF THE LABOR INVOLVED IN THIS PROCESS. GM HAS KNOWN ABOUT THIS PROBLEM AND SHOULD BE RESPONSIBLE FOR REPLACING AND REPAIRING THE DEFECTIVE PARTS USED IN OR

2011-07-12, Structure
1999 CHEVROLET SUBURBAN FRAME FAILURE DUE TO ROT. NOTICED VEHICLE HANDLING DIFFERENT, FRONT END CHECKED ALL TIGHT. NOTICED HOLE IN FRAME UNDER STEERING BOX MOUNTS AND LARGE CRACK HEADING FROM HOLE TOWARDS REAR OF VEHICLE. IMMEDIATELY PARKED TRUCK, UNABLE TO BE DRIVEN UNSAFE. *TT

2010-12-12, Electrical System
GM SIDE TERMINAL BATTERIES HAVE DESIGN FLAW THAT ALLOWS BATTERY ACID TO LEAK OUT OF THE TERMINALS WHEN STRESSES FROM HEAVY CABLES CAUSE SEAL TO FAIL. BATTERY ACID LEAKS ON VEHICLE COMPONENTS BELOW AND HAS BEEN KNOWN TO RUIN BRAKE LINES AND OTHER IMPORTANT SAFETY COMPONENTS. IN ADDITION, THE BATTERY ACID IS HARMFUL TO THE ENVIRONMENT. I HAVE PERSONALLY HAD THESE BATTERIES FAIL SEVERAL TIMES IN MY 99 CHEVY. SUBURBAN K2500 DIESEL. SEE THE LINK FOLLOWING FOR MORE REPORTS OF SAME PROBLEM BY OTHERS: HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/1999/CHEVROLET/SUBURBAN/BATT TOP TERMINAL BATTERIES DO NOT HAVE THIS PROBLEM AS THE TERMINAL TO CASE SEAL IS ABOVE THE LIQUID LEVEL OF THE BATTERIES. G

1999 Chevrolet Suburban 2500 questions

Does the 1999 Chevrolet Suburban 2500 have any recalls?

No. NHTSA has no safety recalls on file for the 1999 Chevrolet Suburban 2500 at this time.

What are the most common problems with the 1999 Chevrolet Suburban 2500?

Based on 12 owner complaints filed with NHTSA, the most-reported problem areas are Service Brakes, Hydraulic (4), Fuel System, Gasoline (2), Electrical System (2).

How do I check if a recall on my 1999 Chevrolet Suburban 2500 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.