2009 Chevrolet Express 3500 Recalls, Problems & Safety Rating

2009 Chevrolet Express 3500 recalls

Most common 2009 Chevrolet Express 3500 problems

Problem areas named in the 9 complaints owners filed with NHTSA.

Problem area	Reports
Tires	2
Fuel System, Gasoline	2
Electrical System	2
Fuel System, Diesel	1
Unknown Or Other	1
Air Bags	1
Vehicle Speed Control	1
Structure	1

What owners report

2017-02-14, Structure
EXTERIOR PAINT PEELS & FLAKES OFF IN SHEETS AS OF NOT ADHERING TO THE METAL. PEELS OFF BOTH WHILE DRIVING & WHEN PARKED. FLAKING OF PAINT IS CONTINUOUS.

2015-10-27, Vehicle Speed Control
TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED TO APPROXIMATELY 10 MPH. THE ENGINE WAS ON; HOWEVER, THE GEAR SHIFT WAS IN THE PARK POSITION WITH NO DRIVER. THE CONTACT MENTIONED THAT THE FRONT PASSENGER SEAT WAS OCCUPIED AT THE TIME OF THE FAILURE. THE VEHICLE CRASHED INTO A WALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

2015-09-01, Air Bags
TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. UPON STARTING THE VEHICLE, THE SERVICE AIR BAG INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ROLL OVER SENSOR BECAME INOPERABLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 59,747.

2015-07-29, Unknown Or Other
I TOOK THE VAN IN TO A DEALER TO FIND OUT WHY THE SERVICE AIR BAG LIGHT IS ON. AFTER PAYING $60.00 FOR A DIAGNOSTICS CHECK, (WHICH I STILL DON'T LIKE) THEY TOLD ME THE ROLLOVER SENSOR NEEDS TO BE REPLACED AT A CRIMINAL $700.00 WHICH I WILL NOT PAY. SOUNDS LIKE A GM ISSUE TO ME SO I CALLED THE HOT LINE AND A WEEK LATER THEY SAID THEY WOULD PAY $200.00 OUT OF THE $700.00 BECAUSE I WAS A GOOD GM BUYER. WRONG ANSWER. SO I FILLED OUT THE BBB COMPLAINT FORMS, WROTE AN ARTICLE ON CARCOMPLAINTS.COM, FILLING OUT THIS FORM, DROPPING OF THE PAPER WORK TO MY ATTORNEYS OFFICE TOMORROW, THEN HEADED TO THE FORD DEALERSHIP. UPDATED 10/01/15*LJ UPDATED 12/13/2017*CN

2014-06-22, Tires
VEHICLE WAS SHAKING. TOOK TO [XXX] INC.IN SYRACUSE, NY FOR ALIGNMENT. WAS TOLD VEHICLE WAS IN ALIGNMENT. WAS TOLD THAT THE STEEL BELTS IN THE TIRES WERE BAD DUE TO TIRES BULGING ON THE OUTSIDE AND INDENTED IN THE CENTER OF THE TIRE. WOULD NOT RECOMMEND TIRE ROTATION. ALL 6 TIRES ARE EFFECTED. THE WORSE TIRE PASSENGER FRONT WAS USED IN THE DATA COLLECTED BY THIS SITE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2009 Chevrolet Express 3500 questions

Does the 2009 Chevrolet Express 3500 have any recalls?

Yes. NHTSA lists 2 safety recalls for the 2009 Chevrolet Express 3500: Equipment Adaptive/Mobility; Equipment:Appliance:Air Conditioner. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2009 Chevrolet Express 3500?

Based on 9 owner complaints filed with NHTSA, the most-reported problem areas are Tires (2), Fuel System, Gasoline (2), Electrical System (2).

How do I check if a recall on my 2009 Chevrolet Express 3500 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.