2004 Chevrolet Avalanche 2500 Recalls, Problems & Safety Rating

2004 Chevrolet Avalanche 2500 recalls

No safety recalls on file for the 2004 Chevrolet Avalanche 2500.

Most common 2004 Chevrolet Avalanche 2500 problems

Problem areas named in the 10 complaints owners filed with NHTSA.

Problem area	Reports
Service Brakes, Hydraulic	7
Electrical System	1
Fuel System, Gasoline	1
Unknown Or Other	1
Service Brakes	1

What owners report

2015-11-26, Service Brakes
BRAKE LINE FAILURE. I WAS APPROACHING A STOP SIGN AND APPLIED THE BRAKES. THE PEDAL WENT TO THE FLOOR AND THE ABS ACTIVATED AND I WAS NOT SLOWING. THERE WAS NO CROSS TRAFFIC SO I LUCKILY AVOIDED AN ACCIDENT. THE BRAKE LINE FAILED DUE TO RUST. BRAKING ABILITY WITH ONLY THE REAR BRAKES ACTIVE WAS VIRTUALLY NONEXISTENT AND THERE WAS NO WARNINGS ON THE DISPLAY. I DO NOT UNDERSTAND HOW THE PREVIOUS INVESTIGATION INTO GM BRAKE LINES WAS DISMISSED.

2015-09-24, Unknown Or Other
WHILE DRIVING DOWN THE ROAD WITH THE A/C ON SUDDENLY THE DRIVERS SIDE STARTS BLOWING HOT AIR WHILE THE PASSENGER SIDE IS STILL BLOWING COLD AIR. IF I PUT THE AVALANCHE INTO NEUTRAL TURN OFF THE ENGINE AND RE START THE ENGINE IT WILL SUDDENLY START BLOWING COLD AIR AGAIN - IT IS HAPPENING QUITE A BIT MORE FREQUENTLY AND I HAVE READ ON SOME AVALANCHE FORUMS OTHERS HAVE HAD THIS ISSUE AS WELL. WHEN ITS 100+ DEGREES OUTSIDE THE AIR NEEDS TO WORK THE HEATER I CAN DO WITHOUT DURING THIS TIME.

2010-05-23, Service Brakes, Hydraulic
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) BRAKE FAILURE CHEVROLET AVALANCHE 2500 VIN [XXX] , MODEL YEAR 2004 DUE TO CORROSION AS DESCRIBED BY GROSSMAN CHEVROLET SERVICE MANAGER BRENT TURCHI ( ROTTED AND LEAKING BRAKE LINE ) - OWNER [XXX] BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR - MR. TURCHI ADVISED THAT BRAKE LINE FROM MASTER CYLINDER TO ABS MODULE ROTTED AND LEAKING - EVENT HAPPENED AT UNDER 50,000 MILES SINCE LINE IS BUNDLED WITH ALL OTHER FRONT LINES IT WAS NECESSARY TO REPLACE 2 LINES FROM MASTER TO BAS, LINE FROM FRONT ABS TO LEFT FRONT AND FROM ABS TO RIGHT FRONT , BLEED AND REPLACE FLUID $608.28 CHARGE. *TR

2010-02-08, Service Brakes, Hydraulic
I FILED A COMPLAINT LAST WEEK, AND READ WHAT WAS WRITTEN TODAY. THE INFO THAT WAS PUT IN YOUR SYSTEM IS INCORRECT, THE ODI NUMBER IS 10305220 THE VECHICE DOES NOT STOP SHORT, IT TAKES ALOT LONGER TO STOP, AS THE BRAKES FAIL DURING ANTI LOCK FAILURES ALSO, THE VEHICLE WAS INVOLVED IN AN ACCIDENT DO TO NOT STOPPING PROPERLY.

2010-02-04, Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 2500. THE CONTACT STATED THE ANTI LOCK BRAKES GOES OFF WHEN THE SURFACE IS DRY. VEHICLE IS STOPPING SHORT BEFORE IT SHOULD STOP. THE VEHICLE WAS TAKEN TO THE DEALER AND STATED THERE IS A PROBLEM WITH THE BRAKES BUT IT IS NOT COVERED UNDER ANY RECALLS AND CONTACT HAS TO PAY FOR THE EXPENSE. THE FAILURE MILEAGE WAS 15,800. UPDATED 03/04/10 *BF THE CONSUMER STATED HE EXPERIENCED EXTENDED STOPPING DISTANCE WHICH RESULTED IN A CRASH. UPDATED 06/14/10.*JB

2004 Chevrolet Avalanche 2500 questions

Does the 2004 Chevrolet Avalanche 2500 have any recalls?

No. NHTSA has no safety recalls on file for the 2004 Chevrolet Avalanche 2500 at this time.

What are the most common problems with the 2004 Chevrolet Avalanche 2500?

Based on 10 owner complaints filed with NHTSA, the most-reported problem areas are Service Brakes, Hydraulic (7), Electrical System (1), Fuel System, Gasoline (1).

How do I check if a recall on my 2004 Chevrolet Avalanche 2500 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.