CarRecallWatchThe 2004 Aprilia RSV Mille has no safety recalls on file with NHTSA.
Owners have filed 3 complaints with NHTSA.
The most-reported problem area is Fuel System, Gasoline (2 reports).
0Recalls
3Owner complaints
0Crashes reported
n/aNHTSA safety rating
Is the repair still open on your RSV Mille?
2004 Aprilia RSV Mille recalls
No safety recalls on file for the 2004 Aprilia RSV Mille.
Most common 2004 Aprilia RSV Mille problems
Problem areas named in the 3 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Fuel System, Gasoline | 2 |
| Service Brakes, Hydraulic | 2 |
| Electrical System | 1 |
| Power Train | 1 |
What owners report
RE 2004 RSV MILLE FACTORY MOTORCYCLE. 5/10/04 HARD TO SHIFT GEARS AND FIND NEUTRAL BECAUSE THE CLUTCH WAS NOT DISENGAGING FULLY WHILE DRIVING. THEREFORE DIFFICULT TO STOP MOTORCYCLE. DEALER BLED CLUTCH LINE. 7/20/04 ENGINE TURNED OFF WHILE I WAS RIDING AT ABOUT 35-40 MILES PER HOUR AND THE REAR WHEEL UNEXPECTEDLY LOCKED UP. ELECTRICAL WIRE AND CONNECTORS MELTED DUE TO ENGINE HEAT. REPLACE AND REROUTED WIRES. 2/8/05 LEAKING GASOLINE FROM THE FUEL CAP. FUEL CAP WAS REPLACED UNDER WARRANTY BECAUSE IT WAS DEFECTIVE. DEALER FOUND THAT THERE WAS NO REAR BRAKE AND NOTED THIS SPECIFICALLY AS A SAFETY ITEM AND THAT AGAIN THERE WAS VERY LITTLE CLUTCH DISENGAGEMENT. NOTE THE PARAGRAPH ABOV
I PURCHASED A NEW 2004 APRILIA RSVR FACTORY MOTORCYCLE IN SEPTEMBER OF 2005. THE REAR BRAKE ON THE MOTORCYCLE HAS NEVER WORKED, MEANING THERE IS NO BRAKING EFFECT WHATSOEVER. I HAVE REPEATEDLY CONTACTED THE SELLING DEALER AND THE MANUFACTURER TO RESOLVE THIS PROBLEM. I AM TOLD BY BOTH THERE ARE PARTS TO FIX THIS RATHER SIGNIFICANT SAFETY ISSUE, BUT I CAN NEVER SEEM TO GET THEM. THERE ARE MANY OTHER OWNERS OF THIS MOTORCYCLE WITH THE SAME COMPLAINT.*JB
DT: FUEL LINE QUICKLY DISCONNECTED ON 2004 APRILIA RST FUTURA. CALLER WAS TRYING TO DISCONNECT FUEL LINE. WHEN IT WAS TOUCHED IT FELL APART IN HANDS. BOUGHT NEW METAL, QUICKLY DISCONNECTED FUEL LINE THAT REPLACED THE ONE THAT BROKE.*AK
2004 Aprilia RSV Mille questions
Does the 2004 Aprilia RSV Mille have any recalls?
No. NHTSA has no safety recalls on file for the 2004 Aprilia RSV Mille at this time.
What are the most common problems with the 2004 Aprilia RSV Mille?
Based on 3 owner complaints filed with NHTSA, the most-reported problem areas are Fuel System, Gasoline (2), Service Brakes, Hydraulic (2), Electrical System (1).
How do I check if a recall on my 2004 Aprilia RSV Mille has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.